Painting and Decorating Made Easier!

Posts tagged ‘Hurricane/Disaster Recovery’

Disaster Recovery, Part 3: When Painting Is Not Enough

Time: 9:00 am; Date: Monday, September 11, 2017. Seven hours after Hurricane Irma moved northward, residents of Central Florida assessed the damages and described their problems.

1. Problem: New, high-durability exterior paint stripped from much of exterior wood. Curled strips of paint hung from the rest of the structure. A dream home, completed three months before storm.
Painter’s recommendations: Replace wood if it’s been soaked by water. When surface is dry, apply two full coats of oil-based primer, using exterior wood filler and caulking where needed. Apply elasmeric coating if the surface is rough. Apply acrylic latex finish if the surface is typically smoother.

2. Problem: Over one-third of wooden rest areas dismantled, including seating, floors, banisters, rails and steps.
Painter’s recommendations: Replace entire area with pressure treated woods. Then stain or paint with oil-based exterior product.

3. Problem: Pool gazebo blown apart, looks like broken Tinker Toy or Lincoln Log set.
Painter’s recommendations: Replace wood, and match existing finish. Or replace the entire gazebo. Then apply a semi-transparent stain for a fast finish.

4. Problem: Ceiling over exterior, three-bay drive-through of hotel lobby’s entrance ripped off. Everything destroyed.
Painter’s recommendations: Install gunite system, then paint using exterior acrylic latex. Gunite is an optimum application, applied by an construction finish expert.

5. Problem: 75 percent of property’s fencing loosened from post braces. Sticky residue
covered manufacturer’s finish.
Painter’s recommendations: Reattach fence sections with fasteners, or use epoxy glue.
Remove residue with lacquer thinner, or non-acetone nail polish remover. Either has less chance of dulling the surface finish.

6. Problem:
Windows of 45 upgraded guest rooms blown out or broken. Rooms a big mess.
Painter’s recommendations: Clear each window frame of glass. Clear debris out of the room. Install temporary wood panels until new glass can be fitted. Repair wall or ceiling damage as necessary.

7. Problem: 130-year old tree uprooted, then toppled onto guest cottage.
Painter’s recommendations: This is an insurance job. Remove tree and cottage. Use part of tree to build something, maybe a custom table top with a rustic appeal.

My message was the same essentially for everyone:

“You’re going to need a lot more than painting. Before any painting can be scheduled.”
RECOVERY TIP: People need to identify and list damages, especially construction-wise. Before their insurance adjusters come to inspect and offer settlements.

PROBLEMS TO RESOLVE BEFORE PAINTING

1. All structural areas, exposed to flooding, water, and/or rain, had to be inspected for toxic
black and/or green mold/mildew; thoroughly dried out by industrial fans, then re-inspected.
Remove or thoroughly clean mold-infested surfaces. Then rinse with warm water. Let dry.

2. Structural areas, construction materials and substrates that emitted odors and/or fumes,
contained hazardous elements, looked discolored, and/or showed signs of 50 percent or more damage, had to be torn out, then removed from the property. According to EPA standards. NOTE: Hazmat (hazardous materials) specialists must be used to handle these removals.

3. Drywall surfaces which have gotten wet through the core must be cut out and replaced.

4. Water infiltration can also leave health-related contaminants which must be properly disposed of. Caution: This job may fall under EPA removal requirements.

5. When cleaning: Protect all skin, hands, face, eyes, etc. from exposure. Provide breathing protection to prevent illness and permanent damage. Example: Full-face breathing apparatus.

6. Limit exposure to paint and finishing chemicals, particularly if you have any breathing or respiratory problem such as asthma, bronchitis, sinusitis, or COPD. Use a full-face breathing apparatus, particularly if you must work around paint chemicals for an extended period of time, and/or frequently.

7. Rebuilding and upgrading is a job for licensed and insured outside contractors. Particularly, heavily damaged areas as described here. Examples of extensive work needed include: new electrical work and plumbing; ceiling and wall joists, drywall/plaster board; window and door frames, doors, cabinetry, fixtures, flooring; etc.

Structures and areas heavily damaged by wind, rain, flooding, toxic contaminants, spillage, waste seepage, etc. require a lot of work before any painter can come on board.

Rejuvination tends to be a long and expensive process. It cannot be rushed or done haphazardly. Many building codes, safety and health standards, and laws are involved. Also inspections.

Bottom line: If you’re a staff painter, you may not become involved at all in the major rebuilding of your hotel or facility. You may not want to be involved.

FOOTNOTE: After a tornado hit my grandparents’ large farm in 1946, they discovered that more than shingles and chimney bricks had disconnected from the house. Sections of plaster had popped (dislodged) from the ceilings and walls in every room. Behind painted and also wallpapered surfaces. My grandfather called it a “farmer-painter’s nightmare.”

*************************************************
Thank you for visiting “Painting with Bob.”

Copyright 2017. Robert D. Hajtovik. All rights reserved.

Advertisements

Disaster Recovery, Part 2: Paintshop Priorities

You may not have much time to get the paintshop back in shape, after a hurricane, or another type of disaster, passes or weakens. In fact, you may need to work that job around the recovery property tasks that you must help others get done throughout the property.

Here are tips on what you might need to get ready right away, or as soon as possible.

ESSENTIAL MATERIALS AND SUPPLIES

1. Throw-away sponges, non-porous buckets, long rubber gloves, face masks.
2. Disposable plastic sheeting, 2-4 ML, duct tape, tarp clasps.
3. Scented bleach – to minimize lingering odors.
4. Non-toxic commercial fungal mold remediation solution, hydrogen peroxide.
5. Fillers, caulking, masonry patch, polyester filler.
6. Sandpaper – assorted counts, steel wool.
7. Interior latex paint – main base colors used on property, exterior latex or oil-base paints.
8. Glues, carpet tile adhesive and tape, mortar mix.
9. Paper towels, clean throw-away rags.
10. Other: Hygienic hand wipes, dust masks; texture for repairs.

ESSENTIAL TOOLS AND EQUIPMENT

1. Scrapers, putty knives, wire brushes.
2. Paintbrushes: 1 ½, 2, 3, and 4-inches; cutting in brush. China bristles and nylon/polyester.
3. Paint rollers and covers: 9-inch x ¼-inch, 3/8-inch, ½-inch, 1 ½-inch.
4. Pressure washer, rubber boots, water exposure gear.
5. Organic vapor respirator
6. Gas compressor..


ESSENTIAL SKILLS AND SERVICES
(more…)

Disaster Recovery, Part I: Hotel/Facility Priorities Come First

The lady walked toward her vehicle in Home Depot’s parking lot. In one hand, she grasped two, 1-gallon cans of Glidden’s Interior Latex Paint. In the other, she held onto a 2-inch Purdy paintbrush, a 6-inch paint roller with cover and an orange combination paint tray and screen.

It was one day after Hurricane Irma, and the tornadoes that it had spawned, had whipped through Central Florida.

When a major disaster hits – eg. hurricane, tropical storm, tornado – painting should be one of the last things on your immediate agenda.

HOTEL/FACILITY PAINTER’S TOP TEN PRIORITIES

1. Help your chief engineer check out all systems that are under the department’s charge – eg. mechanical, electrical, plumbing.

2. As part of the engineering team: (a) assess each building’s condition, interior and exterior; (b) identify problem areas; (c) determine which problems to resolve a.s.a.p., and, (d) decide how to handle each of them promptly and safely.

3. As part of the engineering team, get the department back in shape, so that all of you can do the major recovery and repair tasks and projects as efficiently as possible.

4. As part of the engineering team, help implement the plan to (a) make repairs and (b) get everything up and running again in a timely, safe and cost-effective manner.

5. Assist groundspersons in clearing away all broken trees, limbs and branches and brush; also dismantled lumber, metal, piping; debris, garbage, etc. This includes clearing main traffic areas.

6. Help repair and replace all crucial lighting – especially front entrance, parking, walkways, corridors, lobby, public restrooms. Also repair main walkways, as soon as possible.

7. Assist other departments, as necessary, to get their areas up and running again.

8. Assist chief engineer in working with utility companies, outside contractors, repair services, etc. to get property systems and amenities, and business operations back in working order.

9. Between efforts to help others, start to get your paintshop back in shape. HINT: Try to unpack, then set up what you’ll need to use first.

10. When your chief engineer gives the go-ahead, concentrate your efforts on reorganizing the paintshop so that you can get back to your painting job.

By the way, it can be tempting to ignore the engineering department’s big job during this very disorganized and stressful time. You might be tempted to hide in your area. Do not do it!

This is one instance when painting will be lower on the list of everyone’s priorities.

At the top of every staff member’s and department’s disaster recovery list needs to be:

1. people
2. property
3. business
4. “neighborhood”

This is one time when, both now and later, you’ll be glad that you helped others first.

See: “Painting It: Disaster Recovery, Part 2: Paintshop Priorities.”
See: “Painting It: Disaster Recovery, Part 3: When Painting Is Not Enough.”

******************
Thank you for doing your best job every day. Thank you for visiting “Painting with Bob.”
Copyright 2017. Robert D. Hajtovik. All rights reserved.

Tag Cloud